|
Mubychem Group, is a mature manufacturing company since generations. Engaged in manufacture and supply of Pharmaceutical Intermediates and Excipients, Oil field & fracturing chemicals, Specialty tailor made grades of chemicals in India. With several manufacturing facilities in India and world wide contacts and toll manufacturers we are exporting to all the countries in the world.. |
The company and associated units have certificates & accreditations like FDA - GMP approval; ISO-9001 Certified; "REACH" Registered; ISO-22000; Kosher Certified; Halal Certified; HACCP. We offer Commercial Pure & Pharmacopoeia IP BP USP FCC Food Grade ACS AR Analytical Reagent Grades of Chemicals |
|
--------
Calcium Phosphate Monobasic Monocalcium Phosphate Manufacturers, SDS MSDS Sheet
Calcium Phosphate Monobasic SDS MSDS Sheet, Material Safety Data Sheet of Monocalcium Phosphate
1. Product Identification
Synonyms: Calcium Dihydrogen Phosphate; Phosphoric acid, calcium salt (2:1), monohydrate; acid calcium phosphate; monocalcium orthophosphate; calcium super phosphate
CAS No.: 7758-23-8 (10031-30-8 is also quoted)
EINECS EC Number: 231-837-1
Molecular Weight: 252
Chemical Formula: Ca(H2PO4)2 H2O
2. Hazards Identification
GHS, Globally Harmonized System Classification in accordance with 29 CFR 1910
Classification according to Regulation (EC) No 1272/2008
Skin corrosion/irritation Category 2
Serious eye damage/eye irritation Category 2B
Specific target organ toxicity, single exposure; Respiratory tract irritation Category 3
Labeling according Regulation (EC) No 1272/2008 [CLP]
GHS Label Elements  Irritant |
Signal Words: Caution
Hazard statements:
H315: Causes skin irritation.
H320: Causes eye irritation.
H335: May cause respiratory irritation.
Precautionary statements:
P262: Do not get in eyes, on skin, or on clothing.
P264: Wash skin thoroughly after handling.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P302+352: IF ON SKIN: Wash with soap and water.
P304+P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing.
P305+351+338: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do – continue rinsing.
P332+313: If skin irritation occurs: Get medical advice/attention.
P337+P313: If eye irritation persists: Get medical advice/ attention.
P360: Rinse immediately contaminated clothing and skin with plenty of water before removing clothes.
P362: Take off contaminated clothing and wash before reuse.
According to European Directive 67/548/EEC as amended:
Hazard symbol(s): X
R-phrase(s): R36/37/38 Irritating to eyes, respiratory system and skin.
S-phrase(s): S26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
Full text of S-statement & R-phrases: see section 16
OSHA Hazard: None.
3. Composition/Information on Ingredients
Ingredient: Calcium Phosphate Monobasic
CAS No.: 7758-23-8
EINECS EC Number: 231-837-1
Percent: 98 - 100%
4. First Aid Measures
Always seek medical advice after the first aid treatment.
Inhalation: Allow the victim to rest in a well ventilated area. Seek immediate medical attention.
Ingestion: Give several glasses of water to drink to dilute. If large amounts were swallowed, get medical advice.
Skin Contact: After contact with skin, wash immediately with plenty of water. Gently and thoroughly wash the contaminated skin with running water and non-abrasive soap. Be particularly careful to clean. folds, crevices, creases and groin. Cold water may be used. Cover the irritated skin with an emollient. If irritation persists, seek medical attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes, lifting lower and upper eyelids occasionally. Get medical attention immediately.
5. Fire Fighting Measures
Fire: Monobasic Calcium Phosphate is not considered to be a fire hazard.
Explosion: Monocalcium Phosphate is not considered to be an explosion hazard.
Fire Extinguishing Media: Use any means suitable for extinguishing surrounding fire.
Special Information: In the event of a fire, wear full protective clothing and NIOSH-approved self-contained breathing apparatus with full face piece operated in the pressure demand or other positive pressure mode.
6. Accidental Release Measures
Small Spill: Use appropriate tools to put the spilled solid in a convenient waste disposal container. If necessary: Neutralize the residue with a dilute solution of sodium carbonate. Finish cleaning by spreading water on the contaminated surface and dispose of according to local and regional authority requirements.
Large Spill: Use a shovel to put the material into a convenient waste disposal container. Neutralize the residue with a dilute solution of sodium carbonate. Finish cleaning by spreading water on the contaminated surface and allow to drain.
7. Handling and Storage
Keep Calcium Phosphate Monobasic in a tightly closed container, stored in a cool, dry, ventilated area. Protect against physical damage. Containers of Monobasic Calcium Phosphate may be hazardous when empty since they retain product residues (dust, solids); observe all warnings and precautions listed for the product.
8. Exposure Controls/Personal Protection
Airborne Exposure Limits: None established.
Ventilation System: A system of local and/or general exhaust is recommended to keep employee exposures as low as possible. Local exhaust ventilation is generally preferred because it can control the emissions of the contaminant at its source, preventing dispersion of it into the general work area. Please refer to the ACGIH document, Industrial Ventilation, A Manual of Recommended Practices, most recent edition, for details.
Personal Respirators (NIOSH Approved): For conditions of use where exposure to the dust or mist is apparent, a half-face dust/mist respirator may be worn. For emergencies or instances where the exposure levels are not known, use a full-face positive-pressure, air-supplied respirator.
Skin Protection: Wear protective gloves and clean body-covering clothing.
Eye Protection: Use chemical safety goggles. Maintain eye wash fountain and quick-drench facilities in work area.
9. Physical and Chemical Properties
Appearance: Monobasic Calcium Phosphate is white, crystalline powder.
Odor: Monocalcium Phosphate is odorless.
Solubility: 2 g in 100 g of water
Density: 2.22 @ 18C / 4C
pH: NA.
% Volatiles by volume @ 21C (70F): 0
Boiling Point: 203C (397F)
Melting Point: 100C (212F)
10. Stability and Reactivity
Stability: Monobasic Calcium Phosphate is stable under ordinary conditions of use and storage.
Hazardous Polymerization: Will not occur.
Incompatibilities: No incompatibility data found.
Conditions to Avoid: No information found.
11. Toxicological Information
Oral rat LD50 = 17,500 mg/Kg.
Mutagenic Effects: Not available.
Teratogenic Effects: Not available.
Developmental Toxicity: Not available.
Carcinogenicity: No component of this product present at levels greater than or equal to 0.1% is identified as probable or confirmed human carcinogen by IARC, ACGIH, OSHA and NTP.
12. Ecological Information
Environmental Fate: No information found.
Environmental Toxicity: No information found.
13. Disposal Considerations
Whatever cannot be saved for recovery or recycling should be managed in an appropriate and approved waste disposal facility. Processing, use or contamination of this product may change the waste management options. State and local disposal regulations may differ from federal disposal regulations. Dispose of container and unused Monobasic Monocalcium Phosphate in accordance with legal requirements.
14. Transport Information
DOT (US): Not dangerous goods
ADR/RID: Not dangerous goods
IMDG: Not dangerous goods
IATA: Not dangerous goods
15. Regulatory Information
USA:
TSCA: Calcium Phosphate Monobasic (7758-23-8) Yes
SARA 302: Calcium Phosphate Monobasic (7758-23-8) No
SARA 313: Calcium Phosphate Monobasic (7758-23-8) No
SARA 311/312: Acute: Yes; Chronic: No; Fire: No; Pressure: No; Reactivity: No (Mixture / Solid)
Canada WHMIS Classification: Uncontrolled product according to WHMIS classification criteria
Section 16 - Additional Information
EINECS EC Number: 231-837-1
H315: Causes skin irritation.
H320: Causes eye irritation.
H335: May cause respiratory irritation.
X = Irritant
R36/37/38 Irritating to eyes, respiratory system and skin.
Disclaimer:
***************************
Our company provides this Monobasic
Calcium Phosphate SDS information sheet contained herein in good faith but
makes no representation as to its comprehensiveness or accuracy. This
Monobasic Calcium Phosphate Monobasic MSDS sheet is intended only as a guide
to the appropriate precautionary handling of the material by a
properly trained person using this product. Individuals receiving the
information must exercise their independent judgment in determining its
appropriateness for a particular purpose.
***************************
Monocalcium
Phosphate manufacturers
Monobasic
Calcium Phosphate Monobasic manufacturers
MUBY CHEMICALS GROUP
DONGRI-CHINCHBUNDER, MUMBAI 400009, INDIA
TEL: (OFFICE)
91-22-23770100, 91-22-23726950, 91-22-23774610, 23723564.
e-mail: info@mubychem.com
Global or International Monobasic Calcium Phosphate Monobasic or Monocalcium Phosphate IP BP USP NF FCC ACS Food Grade Analytical Reagent AR Suppliers, Exporters, Importers, Manufacturers
Mono Monobasic Calcium Phosphate Monobasic Monocalcium Phosphate Manufacturers